THE CREATION OF A GAS SENSITIVE SEMOCONDUCTOR SENSOR ON THE BASE OF A MATERIAL, FORMED BY ZOL-GEL METHOD USING ETHANDIOL-1,2
UDC 543.272.2
Keywords:
-Abstract
A Sol-Gel technology approach was used for creation of a sensitive layer of a semiconductor gas sensor on the base of SnO2 doped with Sb2O5 additives (0,15 mol %). Ethanediole-1,2 was utilized in the capacity of a solvent and substituting reagent. On the base of the obtained material a sensor was fabricated and dependence of its signal on the H2 concentration in air was studied. Higher sensitivity of the sensor towards 40 ppm of H2 in air was observed comparing to a sensor made on the base of material obtained via traditional co-sedimentation-from-water method.
References
1. Максимович, Н. П., Каскевич, О. К., Нікітіна, Н. В. та ін. Напівпровідниковий матеріал для адсорбційних сенсорів низькомолекулярних органічних сполук і спосіб його виготовлення // Патент 34593А України. Оп. 15 бер. 2003 року, Бюл. №2.
2. Bond, G., Fuller, M., Molloy, L. Oxidation of carbon monoxide catalyzed by palladium on tin(IV) oxide: an example of spillover catalysis // Proc. 6th Intern. Congr. Catalysis. London. – 1976. – P. 356-364.
3. Prudenziati, M. Present and future of thick film sensors // Handbook of Sensors and Actuators. – 1994. – Vol. 1. – P. 457-462.
4. Samson, S., Fonstad, C. G. Defect structure and electronic donor levels in stannic oxide crystals // J. Appl. Phys. – 1973. – Vol. 44. – P. 4618-4623.
5. Saraladevi, G., Masthan, S. K., Shakuntalav, M., Rao, J. Correlation between structural properties and gas sensing characteristics of SnO2 based gas sensors // J. Mater. Sci: Materials in Electronics. – 1999. – Vol. 10. – P. 545-549.
6. Tamaki, K., Xu, C., Miura, N., Yamazoe, N. Grain size effects on gas sensitivity of porous SnO2-based elements // Sensors and Actuators. – 1991. – Vol. 3. – P. 147-155.
7. Yamamoto, O., Sasamoto, T., Inagaki, M. Indium tin oxide thin films prepared by thermal decomposition of ethylene glycol solution // J. Mater. Res. – 1992. – Vol. 7. – P. 2488-2492.
8. Yamazoe, N., Kurokawa, Y., Seiyama, T. Effects of additives on semiconductor gas sensors // Sensors and Actuators. – 1983. – Vol. 4. – P. 283-289.
9. Zhang, G., Liu, M. Preparation of nanostructured tin oxide using a sol-gel process based on tin tetrachloride and ethylene glycol // J. Mater. Sci. – 1999. – Vol. 34. – P. 3213-3219.
Downloads
Published
Issue
Section
License
Copyright (c) 2007 А. Бувайло, асп., Н. Максимович, канд. хім. наук, Л. Олексенко, канд. хім. наук, Г. Сколяр, інж.
This work is licensed under a Creative Commons Attribution 4.0 International License.
